Product ID:KEL-THANE CLEAR POLYURETHANE VARNISH, 22-SATIN
MSDS Date:10/26/1994
FSC:8010
NIIN:00N036376
MSDS Number: CCSZP

KELLY-MOORE PAINT CO INC

1015 COMMERCIAL ST
SAN CARLOS, CA 94070
US

Emergency Phone: 800-424-9300 (CHEMTREC)

Info Phone: 415-592-8337

Preparer: JULIAN SCHAFER

Cage: 0Y837

KELLY-MOORE PAINT CO INC

SAN CARLOS, CA 94070 US

Telephone: 650-592-8337

Cage: 0Y837

SOLVENT NAPHTHA (PETROLEUM) MEDIUM ALIPHATIC; (MINERAL

CAS: 64742-88-7

OSHA PEL N/K

ACGIH TLV: N/K

NAPTHENES

OSHA PEL N/K

ACGIH TLV: N/K

PARAFFINS

OSHA PEL N/K

ACGIH TLV: N/K

ALKYL BENZENES, C-10 TO C-12

CAS: 68515-25-3

OSHA PEL N/K

ACGIH TLV: N/K

LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:ACUTE: DIZZINESS, HEADACHE, NAUSEA,
CONFUSION, IRRITATION TO UPPER RESPIRATORY TRACT, UNCON, SKIN & EYE
IRRITATION. INTENTIONAL MISUSE BY DELIB CONCENTRATING AND INHALING
CONTENTS MAY BE HARMFUL OR FA TAL. CHRONIC: PROLONGED EXPOSURE TO
HIGH VAPOR CONCENTRATIONS MAY RESULT IN KIDNEY OR LIVER DAMAGE.
(EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HLTH HAZ:LIVER DAMAGE. REPORTS HAVE ASSOCIATED
REPEATED AND PROLONGED OCCUPATIONAL OVEREXPOSURE TO SOLVENTS WITH
PERMANENT BRAIN AND NERVOUS SYSTEM DAMAGE.
Medical Cond Aggravated by Exposure:RESPIRATORY CONDITIONS SUCH AS
BRONCHITIS, ASTHMA, EMPHYSEMA, OR ALLERGIES MAY BE AGGRAVATED BY
EXPOSURE TO SPRAY MIST OR SOLVENT VAPORS. SEE PHYS FOR SPECIFIC MED
OPINION REGARDING CONDITION.

First Aid:INHAL:REMOVE TO FRESH AIR. RESTORE BREATHING. CONSULT
PHYSICIAN. SKIN:WASH OFF WITH A RAG. WASH THOROUGHLY WITH SOAP AND
WATER. EYE:FLUSH WITH LARGE VOLUMES OF WATER FOR AT LEAST 15
MINUTES. GET MEDIC AL ATTENTION. INGEST:CONSULT HOSPITAL EMERGENCY
ROOM OR POISON CONTROL CENTER IMMEDIATELY.

Flash Point:>105F,>41C
Lower Limits:1.0%
Extinguishing Media:USE APPROVED CLASS B FIRE EXTINGUISHER OR
EXTINGUISHING AGENTS SUCH AS CO*2, FOAM ETC.
Fire Fighting Procedures:NIOSH APPRVD SCBA & FULL PROT EQUIP . WATER
MAY BE USED TO COOL CLSD CNTNR TO PVNT PRESS BUILDUP. WATER
SPRAY/WATER FOG SHOULD BE USED CAREFULLY (SUPDAT)
Unusual Fire/Explosion Hazard:KEEP CNTNRS TIGHTLY CLSD. ISOLATE FROM
HEAT, ELEC EQUIP, SPKS & OPEN FLAME. CLSD CNTNRS MAY EXPLODE WHEN
EXPOS TO EXTREME HEAT. DO NOT APPLY TO HOT (SUPDAT)

Spill Release Procedures:EXTING ALL SOURCES OF IGNIT. VENTILATED AREA
TO PVNT BUILDUP OF VAPS THAT MAY ACCUM IN LOW AREAS. FOR LARGER
SPILLS, DIKE AREA W/ABSORB MATL & SCOOP UP WITH NON-SPARKING TOOLS.
SOAK UP SMALL SPILLS WI TH ABSORBENT.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

Handling and Storage Precautions:STORE UPRIGHT IN SEALED CONTAINERS
AWAY FROM SOURCES OF HEAT AND FLAME.
Other Precautions:REMOVE AND WASH CONTAMINATED CLOTHING BEFORE REUSE.
DISCARD CONTAMINATED SHOES.

Respiratory Protection:USE PARTICLE MASK (NIOSH APPRVD TC-21C) TO AVOID
BRTHG SPRAY MIST/SANDING DUST IF LOC VENT IS ADEQ TO KEEP VAP CONCS
W/IN ACCEPTABLE (TLV) LIMS. IF LOC VENT IS NOT SUFFICIENT/WHERE
EXPOS LIMS ARE EXCE EDED, WEAR SUITABLE, PROPERLY (SUPDAT)
Ventilation:LOCAL CROSS-VENTILATION/MECHANICAL EXHAUST SUFFICIENT TO
KEEP ALL HAZARDOUS VAPOR CONCS BELOW PRESCRIBED LIMITS.
Protective Gloves:NEOPRENE/OTHER CHEM RESIST RUBB/PLASTIC.
Eye Protection:ANSI APPRVD CHEM WORKERS GOGGLES .
Other Protective Equipment:ANSI APPRVD EYE WASH & DELUGE SHOWER .
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
FIRE FIGHT PROC:IN FIRE FIGHTING. THIS PROD WILL FLOAT ON WATER & CAN
BE IGNITED ON WATER SURFACE. EXPLO HAZ:SURFS, VAPS MAY TRAVEL ALONG
GROUND & BE IGNITED @ DISTANT LOCATIONS W/POSS FLASHBACK TO HN DLG
SITE. RESP PROT:FITTED RESP (NIOSH APPRVD TC-23C/BETTER) FOR ORG
VAPS WITH NIOSH APPRVD DUST FILTER AS NEEDED.

Boiling Pt:B.P. Text:>300F,>149C
Vapor Pres:SEE ING 1
Vapor Density:HVR/AIR
Spec Gravity:0.89
Evaporation Rate & Reference:SLOWER THAN ETHER
Solubility in Water:NOT KNOWN
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
Percent Volatiles by Volume:59-63

Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:HIGH TEMPERATURES, IGNITION SOURCES.
Hazardous Decomposition Products:MAY PRODUCE HAZARDOUS FUMES WHEN
HEATED TO DECOMPOSITION OR COMBUSTION AS IN WELDING OR FIRE.

Waste Disposal Methods:DISPOSE IN ACCORDANCE WITH LOCAL, STATE AND
FEDERAL REGULATIONS. INCINERATE IN APPROVED FACILITY, BUT NOT IN
CLOSED CONTAINER.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.